Umicore acquires battery recycling for Tesla Motors in Europe

Tesla Motors released details of the recycling strategy for its battery packs in Europe.

To develop in the future with more and more electric vehicles on our roads increases, so does the need for approaches to recycling of traction Dell Studio 1737 battery. The automotive industry was already facing a similar situation, so as a recycling solution was for the 12-volt lead-acid starter batteries to find the car to come in every day use. Meanwhile, these batteries are among the products with the highest recycling rate, the U.S. Environmental Protection Agency estimatesThat today 99% of all lead acid batteries to be recycled.

The U.S. firm Tesla has now announced that it will let its lithium-ion Dell Inspiron 6400 battery recycle at the end of their lifespan in the UHT system (Ultra High Temperature) of Umicore in Belgium. The Brussels-based company will recover from the spent battery packs cobalt, nickel and other metals.

“We see the recycling program by Tesla Motors over the last few years have improved. Before we send the packets to the Dell Latitude E6500 battery recycling, we can re-use is already about 10% (by weight), for example, the battery case and some electrical components. In North America we are working with the Brothers Kinsbursky to recycle about 60 percent of the Dell Vostro 1500 battery pack. In Europe we have now begun to cooperate with Umicore, and soon we will also news on recycling in Asia, “writes Director of Tesla’s Energy Storage System, Kurt Kelty, in a Blog.

According to Tesla Umicore converts the cobalt in a high-grade cobalt oxide lithium-order, which can be sold to battery manufacturers. Some of the few by-products arising here is a clean inert slag, which contains calcium oxide and lithium. The slag can be used to produce high-quality concrete.

“Nearly 5 percent of global man-produced CO2 emissions arise from the production of cement. This raw material substitutes to replace, reduce CO2 emissions and the consumption of non renewable resources is considerable. This “byproduct” of the construction industry offers the possibility replacement products as an environmentally friendly alternative, “says Kurt Kelty further.

The recycling technology will enable Umicore to save 70% of CO2 emissions, since the residual plastic materials during the melting process generate so much heat that no additional energy is supplied from the outside.

Tesla builds and sells in three years the Tesla Roadster. During this time, the Silicon Valley-based company for recycling and the use of non-toxic substances has been established. Tesla customers must pay for the recycling of the Dell Inspiron 1520 battery pack anything when it is removed after seven to ten years or 160,000 miles.

Researchers develop batteries can be recharged in a few seconds

At the University of Illinois, researchers succeeded in developing a dreidimenisionale nanostructure. This allows significantly faster charging batteries.

Developed by researchers at Paul Brown batteries not differ externally from burlap and batteries. The difference lies in the cathode used for the three-dimensional nanostructure. This makes it possible, a HP Pavilion dv6000 Battery for a mobile phone in a few seconds and a notebook battery in a few minutes to reload.

Normally, a conventional battery is aging much faster if you increase the amperage for charging. These DELL XPS M1530 battery behave like capacitors, however, with the storage capacity of batteries. The researchers have achieved by having transformed the active storage material into a thin film with a three-dimensional structure. This makes it possible for these batteries in a very short time, then recharge a few seconds to minutes and to discharge again. The highlight: The HP Pavilion DV5 Battery does not suffer from the fact that life should be as high as current batteries. The researchers demonstrated at 10 to 100 charge cycles.

With diesr technology can build phones that are fully recharged in a few seconds, it takes a little longer for laptops but also just a few minutes. Interestingly, this technique is also suitable for applications where high currents are always needed, such as defibrillators. The technique would certainly also in other areas most welcome, just think of DELL Studio 1537 battery or electric toothbrushes, for example.

Brown also sees great potential in electric cars, because there is still plenty of time necessary to recharge the Dell Inspiron 1501 battery again, usually 8-12 hours. If suddenly the batteries within a quarter of an hour were back fully loaded, it could help the electric car to the final break.

The processes that were used for the invention are in the industry today is already widespread, so it would integrate without much effort to be the technology into existing systems. The results of the research was on 20 March in Nature Nanotechnology Magazine published. Sun is also promising, this message, the whole has a great hook. 2009 Researchers at MIT have developed a very similar technique that builds on existing technology and could be easily accommodated in a short time to market.

Since then again past two years without so much as a single handset manufacturers have integrated this technology into their devices. Really understand, because a mobile phone that can recharge in 10 seconds, would actually be a compelling selling point and could provide the first integrated manufacturer of the technology a significant market advantage.

Hope that such innovations will finally reach the market and not more than a good idea once again disappear in the drawer.

Operation and maintenance of laptop batteries

Laptop battery on gasoline and cars as important as the relationship between the notebook biggest advantage is its ability to rely on built in battery has some life. Daily charge for the Dell Inspiron 1525 battery problems with a lot of controversy conservation,

Notebook Batteries each have their own arguments, each have their own opinion, at the end, the proper use and maintenance of laptop batteries be?

Many different types of batteries, such as early alkaline manganese batteries, lead-acid batteries, now common nickel-metal hydride batteries, nickel-cadmium batteries, lithium batteries, lithium-ion battery and is designed to gradually apply the fuel cell, micro-batteries, different types of batteries due to structural differences all have their own unique characteristics, and what the normal operation can not be generalized. Before the Dell Inspiron 6400 battery is almost uniformly for the lithium-ion structure, have very early products in other types of batteries that are the source of a variety of arguments have been used, but in time, these batteries should be scrapped will have many years There is not much discussed.

1st Activate

We are ready to activate the new notebook computer, you must first understand the lithium-ion battery is not as obvious as Ni-MH battery memory effect, the new DELL XPS M1530 battery have already been activated, the so-called third put the new Battery is not afraid of three pulses can not be activated, but also a certain degree. We often hear that the new battery the first charge of not less than 12 hours, so check the depth of the lithium-ion battery, do not know, especially with an intelligent laptop battery protection circuit when the battery is fully charged, it will automatically disconnect the external power source, the so-called “activation depth of 12 hours,” it’s just wasted energy. Some manufacturers suggest using the guidelines that should be long before the first use toll models, closer attention to prevent direct access to electricity, only about half of the Dell Vostro 1510 battery were significantly shorten the lifetime of use and misunderstandings caused by the user.

2nd Save

Why are companies we are only half the battery charge, and separated it with the laptop? This is because the case is not used in a long time, because there will still be too slow lithium-ion battery discharge phenomenon to cause no damage to the battery unused for long periods, preferably in the battery 40% to 60% of the time and notebook battery has disconnected from a computer. If you are not a long time, preferably about every 2 to 3 months to come to the Dell Inspiron 1520 battery, the battery in a better state of maintenance recharge.

3rd Use and protection of

In the long-term use, we will notice that a laptop battery is reduced significantly, this is actually due to its capacity with damping, which is normal. Lithium-ion battery during operation, electrode material remains solid precipitate, the solid material can not be broken in the electrolyte or other contaminants. She constantly applied to the electrode directly to effective reduction of the electrolyte, the corresponding reduced capacity, life can not lead the fixed time, at least, that is, the so-called “battery” or “cycles” to the.

Many friends are lithium-ion battery is plagued by (there is some misinformation, can that lithium-ion battery is only 300 to 500 times) that began around the battery as long as the count done free of charge on a single charge . Correct to say: completion of lithium charge cycle life and time to, and not directly related to the number of charge cycles. A charge cycle means that all the energy from the HP Pavilion DV5 Battery full to empty, and then by air to the whole process. Easy to understand: a lithium on the first day only half of the electricity, and then charge it. If the next day so, that is, on the charge by half, a total of two charge is dropped, it may be possible only as one charge cycle instead of two, usually after many charge, a complete charging cycle are counted. If the battery management software and hardware support for control, you can also power up when they need battery to extend battery life for free.

Flexible use of laptop battery management software is the key to longevity, as Tinkpad set the Power Manger, Asus Power4Gear, the software in detail the various situations in connection with the various components within the notebook, it was and the length of life the battery. Windows7 energy options in the type of work can be done, but put a little complicated, and no brand expertise with the software so easy.

When using the laptop’s external power supply, the need to disconnect the battery problem is more controversial. Some have argued that the battery won on the grounds that such use will heat the battery is always in the state, which is the life of the battery or the Dell Inspiron Mini 9 battery always in charge, the battery is overcharged batteries are damaged. But we already mentioned, make sure if the laptop’s hardware and software design, clearance, protection circuitry and software can ensure that the battery will not overheat or be charged. Then put it mildly, in the external power supply, the battery actually played a UPS function, the voltage instability of the computer are made available to more stable current and voltage, which is relatively sensitive to the mobile platform is very important, and as a notebook battery price the value of internal data that is important? How to choose, who would should be a few hearts.

4th Some of the basic annotation Notebook Batteries

Limited appearance, all models of laptop battery brand is not in the same style, but the interior is pretty much the same. Often said that the 4-cell, is 6-cell battery and is thus used to describe how many internal lithium-ion batteries in series (8-cell battery with high capacity batteries not for two, four small batteries in series and then parallel), the advantage is that ensuring security in the comparison (relatively high-capacity battery production difficulties that an independent, but a problem more easily damaged or even explode), but also easy to replace. Strong practical ability for friends to replace open the outer plastic shell laptop batteries, batteries, welding lead this kind of work should be very easy if you have no confidence in the ability of the professional service can also help a number of sites, the overall cost significantly less than the original purchase of new products.

And the recent battery, we will find a variety of options selected, in addition to other stress that some manufacturers will mAh (milliamp hour) replacement Ah (ampere hours) or Wh (watt-hours), it is easy to confuse. Is actually quite simple, yet Oh power supply, the current X time, and 1A = 1000mAh, 1Ah = 1000mAh. The Wh actually more fully correspond to the height of the HP Pavilion DV7 Battery to do the work that the power X time, the first two sets and battery voltage of the product. Be characterized, for example 4000mAh, 11.1V battery, 4Ah or as 4.44Wh (4AhX11.1V).

Myth for Laptop battery

Myth: You can also use a compatible charger

Laptop power than mobile phones, the most extreme case, power supply and the need to recharge the battery while the engine is running at full speed to the power necessary to meet, laptops generally do not have a compatible charger for all models of the voltage , Electricity or interfaces can differ, often a wide variety of notebooks, "a compatible charger" is probably more expensive than the original Dell X284G battery charger, also if the same interface, if the voltage and current under the nominal value of the machine The machine runs on Full speed when the battery charging current may not be sufficient, which received a lot of damage to the battery. If the voltage and current much less than the face value, and even found it impossible to launch or boat will not be charged, so choose the best time, the power and the first woman the same choice, it can not be found? It should be noted that a certain tension and Stream with the nominal value of the machine according to the interface with the system is usually the same for different products, but the voltage and current may be different, be sure the To pay attention to this point!

Myth: battery must be fully charged (or put photovoltaic) preserved

Whether fully or shine, in fact, is not properly set, the long-term preservation photoelectric batteries lose their activity and even the control circuit protection self-locking and can not use again, full power will bring long-term archiving Security risks, the best method of preservation is the relief to 40% and then save, the fear of high humidity and temperature lithium Dell Studio 1737 battery, it should be placed in a cool, dry place, but the temperature not too low, otherwise strongly reduced the capacity , About 20 degrees Celsius is ideal for maintaining the temperature.

Seven errors: Batteries die, you can also charge your batteries

Many people replace the battery is like a deadly, it seems that manufacturers have long been expected to do so, and many brands of Laptop batteries are designed with self-locking function when the Dell Inspiron Mini 9 battery enter the control loop of the circuit to the self- To unlock locked state, only the use of special tools, not before the loop will work, that is the have the same scrap batteries, rechargeable batteries laptop batteries are not free to change the batteries, the batteries, if not change, please remember Look for special maintenance of the DELL Latitude D620 battery companies to make the work that their own waste for a small effort, the type the effort is not for the frustration and depression at the miserable.BTP C2BM

Eight error: Less than 99% since then charge 100% of the costs continue to explode

Laptop battery explosion almost no chance at best a series of shell melting heat problem, but few can cause a fire, was a few Incidents has been released, is the fact that production, if the poor in the short-circuit caused by the use were of lead, even if it is the most species have short circuit protection circuit disconnects the battery Buzhi Yu significant damage, unless they are found in the protection of the circuit the Dell Inspiron 1545 battery short out (before the time of Compaq laptop battery explosion was should be created), so Things that have come into contact with the notebook in my 3 years ago seen only in two cases. Instead, things as your phone number, or the quality of the battery problem in the final analysis, a large number of low-quality installation of mobile phone batteries and almost never sell these laptops Battery, since no models to have a sufficiently largeWarrant produce compatible battery.

The reason why, after charging to 99% less than 100%, often because the battery control circuit of the records and the deviation of the state of the battery itself, the Dell Inspiron 640m battery has reached the record of the voltage control circuit, so that the power Control group, was commissioned, in fact, the battery was full, the problem can usually be corrected by the correction, but even without calibration has nothing to do, because most of the Charging circuit will not automatically be filled after a long break and even smart auto-refresh 99% of the current record is 100%, even a fool is non-stop design, but also because the current is very small at this time without causing damage.

In the current notebook batteries are basically the temperature detection circuit when the temperature of the Sony VGP-BPS13/S battery is too high to separate the control circuit of the battery would most likely force to prevent the temperature is further increased so that this situation fully to the explosion Notebook Computers Batteries in place not less chance of winning the jackpot.

No matter how scientific maintenance, the battery is getting older, what is the magic cosmetics and beauty care can not prevent an old woman, at best delay, the only way to avoid the aging of the battery is not to use (so many People choose to get the battery), but this is meaningless, but the laptop batteries ... always with the use of longer maturity period, is actually a semi-consumables for almost all manufacturers of Notebook computers, regardless of how long the host to guarantee the warranty, the battery usually only for one year.

If you want to introduce a weekly battery was about a year later calculate Care 60% to 70% of the capacity of the HP Pavilion DV5 Battery of my own probably the case, look at the battery when it is increasingly felt exhausted a kind of torture for you, the best method is to take down not and do not pray, or kick the power plug, or is it a buy as a backup, as long as the battery and notebook to value and fun bring enough, I think it is the sacrifice worth it.

Some contents from:http://laptopbattery1.livejournal.com/

The battery on the Dell Inspiron 1525

About Dell Inspiron 1525 battery Use: Whether battery is completely empty discharge affects the battery life have, there is no need to recharge the battery runs out before the general charging power management software prompted, and then the adapter for charging. Long-term use AC when you remove the battery? First Most of the current brand of notebooks, including Lenovo, have intelligent power management features, excellent power management circuit and load-management system will be stopped automatically after the Dell Inspiron 6400 battery is fully charged the battery, so AkkulaufzeitDas life is as good as any Wirkung.2. Data and the laptop battery are much more valuable, has violated a sudden power failure, not only the laptop, it can not be stored documents or data loss. From this perspective, connected to the DELL Studio 1537 battery is gut3. Long without battery, the battery should be stored at room temperature in a dry place, battery remained at 30% -50%, usually about 2-3 months, once the battery is fully charged and discharged. Of course, the decisive specific time or in the computer's instructions. How to extend laptop Akkulaufzeit1. Reduce the brightness of the screen, the screen is power-hungry, demanding the guarantee is not visible on the premise that not only can the brightness of the display to save power, but also to protect their eyesight. Shortcut: "Fn" + Pfeiltasten.2. Lower the volume. Use the keyboard to the top of the "one-click video" Touch button to set, or the shortcut: "Fn" + left Pfeiltaste.3. Use of standby, sleep and other functions. How long without a computer so that the notebook is in standby or hibernate, saving power and extending the life of Computers.4. The easiest way is with the Lenovo notebook's power management software, the balance or power saving mode, both to ensure the use of speed, not the computer does the energy consumption battery brand senken.Diese Medion Battery, Is the model Dell Inspiron 1525 Battery.

Cell Type:Li-ion
Voltage:11.1V
Capacity:4400mAh
Cells:6 cell
Weight:500g
Color:black
Product ID:DL034
Dimensions: Condition: brand new,replacement,100% OEM compatible

Compatible original Battery Code:

• Dell GP952 battery
• Dell RU586 battery
• Dell RN873 battery
• Dell WK379 battery
• Dell X284G battery
  
• Dell XR693 battery
• Dell GW240 battery
• Dell GW252 battery
• Dell 312-0625 battery
• Dell 312-0626 battery
• Dell 312-0633 battery
• Dell 312-0634 battery

Laptop Battery Fits Models:

• Dell Inspiron 1525 battery
• Dell Inspiron 1526 battery
• Dell Inspiron 1545 battery

Some contents from:http://laptopbatteriesinc.weebly.com/

50% percent of the energy density of lithium batteries

Can save a new lithium-ion batteries for more power, more than the previous model, while a good performance, adaptation to high temperatures. It may prove to be valuable, can be used in hybrid vehicles and electric vehicles, the use of high-density Dell Inspiron 1720 battery usually have a security risk.

Layton Energy Corporation (Energy Leyden) with a graphite collector imide and sodium (sodium imide), used in the battery electrolyte. These materials have a longer battery life, can withstand higher temperatures, Leiden company has refused to discuss how they can achieve higher energy density.

The company said that the Dell Latitude E4300 battery energy density of 225 watt-hours per kilogram. This is a high-end range of laptop batteries, approximately 50% higher than the lithium-ion battery is the type of electric car use. The four years old and the new record company, want to see the batteries in flat-panel computer manufacturer should have used this year, said President Askar ? suffering Patel (Aakar Patel).

Lithium-ion HP Pavilion Dv9000 Battery are widely used in consumer electronics products, but need the design to ensure that they are safe performance, change to electric cars or hybrid vehicles. Automobile manufacturers often have to use a lower density of the battery and the use of electronic devices and cooling systems to ensure that the Dell Studio 1735 battery cell is not too hot. For example, Tesla Motors (Tesla Motors) similar to those found in notebook batteries deployed in and used to drive by Lou De Sida (Roadster) Roadster. The company uses liquid cooling and thermal management of electronic devices and software to prevent overheating and other problems.

Cathode materials such as lithium iron phosphate (lithium iron phosphate) is sometimes used in electric vehicle batteries, because they have high temperatures. Trade-offs, it has relatively low energy density, about 140 watt hours per kilogram.

Layton concentrated electrolytes and collectors, as this both the performance of anode and cathode is affected and helps to determine the Dell XPS M1730 battery life and stability, said Patel. The result is a very good battery performance, temperature as high as 60 ℃ can be, he added.

Replacing the lithium battery Layton (lithium) which has a lithium-ion battery component replacement imine sodium (Na-imide) is. And lithium, it does not react with water in the battery, this reaction will greatly reduce battery life. Lithium starts decomposing at room temperature lose their effect, which is becoming more obvious when the temperature reached 55 ℃. Imide sodium do not decompose at high temperatures.

However, there will be trouble sodium imide, will corrode the aluminum collector, this collector is usually found in the Dell Vostro 1510 battery unit. Graphite could be a good alternative because it is not such an attack. He said: Who Carter ? Srinivasan (Venkat Srinivasan), said he was the Lawrence Berkeley National Laboratory (Lawrence Berkeley National Laboratory) Scientists “The key to progress is not for the electrolyte suffering Take Amazingly, not with aluminum collector.” the attention has been on the company’s technology. “This change, so that they the electrolyte.”

Patel said that the Dell Studio 1737 battery can be air cooled instead of liquid cooling, which makes them cheaper and portable use. The company is also developing battery management electronics and software to prevent, to excessive costs or less charge, these questions will affect battery life, he said. Suffer Company recently received $ 2,960,000 in financing a project from California, is the monthly production of 10 cars batteries.

“Show Lleyton battery technology to the very real benefits, for car batteries and in the thermal management, life cycle performance and energy density,” Brian ? WSM (Brian Wismann) said that he DON Mon Corporation (Brammo) Director of Product Development interested the company is developing electric motorcycles, Leiden, the company effectively use the technology.

Layton new technology first appears in the notebook computer DELL XPS M1530 battery. The company said that these batteries reach more than 1,000 charge-discharge cycle 300 cycles of conventional laptop batteries, can be compared and have three years warranty instead of the usual one year warranty.